transfer case

Got to play a bit this past weekend up at AoP in TN. My Jeep has always made a lot of noise in 4LO, when the drive line is loaded up and I need to hit the clutch to keep from stalling. Its a clattering type noise identical to these two videos below: Broken Arrow - Sedona AZyoutube.com...

I'm new to owning a LJ (just over a week now) and already modifying it :) I will be taking it off road very soon and the trails have some rock climbing spots, anywhere from easy to "no way am I going there in this Jeep". I have the following... 2" OME lift 1.25" JKS body lift 1" motor mount...

Not sure what’s going on possible transfer case or transmission Jeep has 132,xxx miles and I recently installed a 3” lift and 31.5” mud terrains and it ran fun for a couple of months with mild off roading here and there. I was driving for about 30 min at around 70 and then traffic became to a...

I know many of you Gods of Infinite wisdom have some good ideas about this one. My factory linkage is about junk, like most of you know happens. Plastic bushings are gone; rattles, don’t know how it still works! I was just wondering which method you guys highly recommend, since I only want to...

Not sure if this is the spot to post this. I bought a 01 Wrangler, Manual, With a 3 inch lift. Typical issue where 4x4 is bound up because of the angle. So I disconnected the rod to release 4x4 and just driving it in 2 wheel right now. Before I spend money on the Cable system, I want to make...

Is there any difference between a NP 231j T-case that was mated to either a Automatic or Standard trans? Both behind a 6cylinder and same year TJ, 06. I was thinking about buying a T-case ( I found one for $100) and doing a sye and any other maintenance on it and when all complete throw it in...

Was just browsing some build threads elsewhere and saw that a good while back it was somewhat popular to flip a dana 300 for use in a tj. Just curious if anybody has first hand experience with the project. Seems like a decent idea as you could attain about 7-9" extra driveshaft length in the...

Hey Guys, I bought a 2003 Jeep TJ recently with 90k miles and it has a noise coming from the Transmission/Transfercase area and I am trying to figure out what is causing it. It is a knocking/ticking noise that increases as I accelerate and doesn't happen when I rev the engine in neutral. Its...

For sale: NP-231J stock TJ wrangler transfer case with the "Long" 32 spline input shaft for sale in So. CA area $250 takes it, pickup only. This fits both the 4 & 6 cylinder AUTOMATIC Wranglers with the 30RH & 32RH transmissions from 1997 to 2002 model years. One can cut down or trim the input...

Okay. So we swapped the transfer case. It did fine for a week. Then we loose 2.4.R. It's like they vanished. I did pull back the boots and shift through the gears. But the neutral seem back and when put into 3rd there's like and inch clearance above it. Anyone know? Suggestions? Looking...

Boyfriend bought a 99 wrangler tj 6L manual transmission First the rear end went out. After getting it back the transfer case blew up. I cant figure out which transfer case we need. Heres what info I have. Model # 231 J Assy # 5209 9211 Serial # 7 24 98 2 Ratio # 272 Help?? I can't seem to...

I've been researching TT, especially the well-written thread on this forum, and pages on Tom Wood site. If I'm understanding, since I already have a 2.5" OME I can go ahead and do a 1" MML Brown Dog to get rid of my TC drop. I can do a Novak Transfer Case Shifter anytime. I can also do a 1"...

Hey guys so I decided to offer a little tour of my jeep,I made a video about it! hope you guys can enjoy!

Hey all. I need some opinions. I have an 03 Sahara, NV3550 5 spd and 231 J t-case. I have developed over the last 2 months a very loud bearing noise when I let off throttle, in all gears. Even coasting in neutral it is there. If I throw the t-case in neutral when coasting, it goes away...

What is a tummy tuck? Take a look under your Jeep Wrangler TJ and one of the first thing's you'll notice is that the transfer case hangs down really low (especially if you have a Rubicon model). A tummy tuck means that you're lifting the transfer case up into the body more and getting rid of...