Search results

2004 6 cyl 85000 miles Initially diagnosed as rough idle. IAC valve was removed and cleaned. Now, just after start up, when accelerating from stop, get slow engine acceleration as vehicle slowly stumbles up to speed. Eventually (10 - 15 secs) it will accelerate as normal. You can feel it...

Getting intermittent check engine light with p0138 code. I bought this 2004 TJ last Sept then stored it for winter. It runs well but the CEL has been on again off again since I bought it. About 85000 miles. Fuel mileage seems poor (although with my lack of Jeep experience I don’t know what...

I picked up an older, but unused TrepTop NX for my '04 TJ. Inside the aft corners, where the plastic corner support piece slides in, I found an 18 inch (approx) fabric tube (sewn but open on both ends) which is made with same material as the actual top. It was doubled over and slid inside of...

What's the standard (Mopar Man Trans fluid) MS-9224 equivalent / replacement in Canada? I tried to order the Mopar stuff on-line but it's supposedly no longer available / produced? And it's likely just another product relabelled and sold as "Mopar special" at inflated prices anyways...blah blah...

97-06 Jeep TJ’s. My relatively new-to-me 2004 Sahara (6 cylinder) has 15” wheels which I’m assuming are stock. My buddy says the TJ’s also came with stock 16” wheels. Is that possible? His is 2006. Thx Rol1964

I found a set of 17" wheels with tires off a Liberty (year unknown) for an acceptable price but I'm not sure if they are compatible. They are 235/65R17's mounted and balanced on 5 x 114.3 aluminum wheels. Wheel sizing for 17" wheels on the TJ (from "wheel-size.com" ) shows: 245/65SR/17...

Howdy folks. Happy New Year to you all. Can I get a set of 17” jeep wheels that will fit on my ‘04 without need for adapters? What specific years / models of Jeep will be a fit? 114.3’s are stock. Not sure about the offset etc. I’m searching in my local used market. Searching for a set of...

My 2004 has (mostly) been stored winters (based in Eastern Canada so harsh winters with salt etc) so it’s in pretty good shape. However, there is quite a bit of crud built up inside the forward frame rails with flaking metal due to interior corrosion (the rear was drilled for drainage but not...

Hey folks. I need to replace the 2 pin plug on my RT side factory fog lamp (on the main harness side) as the lock tab will not engage so I have a loose cnxn / no light. I can rewire it with any old scrap of wire and a couple of connectors but I prefer to replace it with a factory plug cause I'm...

Are these typically selected on via the headlight switch? Hi beam position...? Or is there an extra switch supplied when they're installed? Thx.

I may have found the answer to my own question here, but is the power wire in the 6 wire hard top plug the black / white wire? Thx.

I have read that replacing upstream (sensors 1 on both banks) O2 sensors will improve fuel economy. Is it similar for the downstream sensors if replaced in pairs? Thx Rol1964

A very nice local dude gave me a rear trunk. It fits well and the holes line up perfectly but there's no nuts on the inside of the fenders on my TJ Sport so .... it's stupid question time: do I have to drill from the other side to make this factory option seat in properly... or is my Jeep...

How can I check part numbers to see if a soft top from a 2014 2 door will fit my 2004 TJ? I'm doubtful but it could be a great deal if it will fit...! Thx, Rol1964

I have the 0138 code (CEL was intermittent but now appears to be more "on" than "off") on my new to me '04 TJ 4.0 135000 kms / 80000 miles. I read somewhere that it's best to replace O2 sensors in pairs i.e.: both downstreams or both upstreams or all four at any time you replace. So is it...

2004 TJ Sarah 4.0 First Jeep. Does the frame have drain holes for accumulated water drilled into the lowest point? I washed it today and noticed water pooled inside the frame in what appears to be a drain hole but this is located well above the lowest point so the rinse water just sat...

I'm attempting to repair a repair, by previous owner. I have the kit to reattach the electrical terminal however, whoever did this the last time appears to have gotten carried away the the sandpaper and removed most of the conductive paint at the point where the tab is glued on (wide strip from...

I am looking at replacing the original soft top on my '04 Sahara as the stitching and velcro are failing, the zippers are crusty and it is an absolute bear to get on! The websites show tops with prices ranging from $250 to $900. I understand that you get what you pay for but what else should...

New to me 2004 Sahara 4 liter. I have no dome lights or buzzer. Positions 3, 16 and 20 in the fuse block are empty. Anyone know which circuit these are on? Many Thx.

Winter rated tires are mandatory where I live. It's common therefore to buy second hand steel wheels with winter tires mounted to use as sacrificial wheels in our wicked winters! Assuming I can find 17" take offs or aftermarket wheel and tire sets, can I put those on without any adapters? What...